I finished building the shed window frames as shown below. They are ready for my DW to paint when she gets the chance. As I have noted in previous posts, these are 2'x3' and will end up costing about $10 each, including glass and hardware.
![](http://i3.photoblog.com/photos2/13008-1223954248-6.jpg)
All four of these will be tip-in windows - the tops will tip inwards about 8 inches to allow ventilation in the summer time. The bottoms will be hinged.
Building the window frames
The general construction of these frames is a lap design (similar to the doors). This is really simple and makes for a very strong window. This technique also makes use of some of the short cut-off ends from the trim and doors.
The following diagram should help you understand how the process works...
![](https://blogger.googleusercontent.com/img/b/R29vZ2xl/AVvXsEjjtLC2vGYkyHOpMXcii1AUubAmQbJhmMqaMB4_9m6z_k_ZpRaZp9caTVSaB3lxhjtvIPANM60XVvRzEGf7T9sMxeDmXo40KFLa0tWp7HYw6yo5J1Al_wDyZzNpkZRRK52EVoKE/s400/Image002.jpg)
First, I built the "blue" parts. These are assembled with 2" brads through the cross-pieces (using an air nailer) and Titebond waterproof wood glue. The cross-pieces are cut extra long as shown. I align one side (in this case the right side), and let the other side extend over. You can cut them to exact length if you want, but I prefer to trim everything off at one time.
![](http://i3.photoblog.com/photos2/13008-1223954248-1.jpg)
Then I build the "orange" parts. These are really simple - glue and 1.25" brads. The outside pieces have the support rib aligned to the edges, and for the center piece, I align it up the middle (shown). The support ribs will overlap the "blue" end pieces and make assembly easy.
![](http://i3.photoblog.com/photos2/13008-1223954248-2.jpg)
I assemble the frames by gluing and nailing the "orange" center pieces to the ends. Here is a picture of the front side. Notice that the cross pieces and support ribs are long, except on the bottom, where I took the time to align everything.
![](http://i3.photoblog.com/photos2/13008-1223954248-4.jpg)
Here is a picture of the back side. Where the cross-pieces and ribs overlap, I use a 1.25" deck screw instead of nails. I pre-drill the holes to avoid the wood splitting. One screw at each overlap should give plenty of strength to the frame (screws are not shown in the picture).
![](http://i3.photoblog.com/photos2/13008-1223954248-3.jpg)
Once assembled, I use the table saw to clean up the edges.
![](http://i3.photoblog.com/photos2/13008-1223954248-5.jpg)
Now that the frames are assembled, we will paint them, then attach the glass using a few support clips and silicone caulk. I will attach hinges to the bottom and a small bolt-latch at the top.
![](http://i3.photoblog.com/photos2/13008-1223954248-6.jpg)
I'll take pictures of the installation, showing how they tip-out.